Trailers / In shop only
Expandable Trailer Repair in Yorba Linda
Expandable trailers combine a hard sided body with sliding bunk ends, and the interface between the two is where they fail. Bunk end slide mechanisms, their seals and the surrounding wall opening account for most of the work.
An expandable puts a large opening in each end wall so a bunk can slide out. That opening weakens the wall and the sliding bunk loads it every time it is deployed.
Two problems follow: the opening distorts, and the seal that depends on the opening stops working.
Why do bunk ends start leaking?
Because the wall opening has moved. The bunk seals against the opening perimeter, and any distortion there produces a gap that no amount of new sealing material fixes.
The other cause is the bunk itself sagging on worn slides, which drops the sealing surface out of plane. Both are mechanical rather than sealant problems.
- End wall opening distortion around the bunk
- Bunk slide mechanism wear and sag
- Perimeter seal failure from a moved opening
- Bunk end floor and frame damage
- Tent fabric wear where a soft bunk end is used
- Interior water damage below the bunk opening
How is the bunk opening corrected?
Measured against its original geometry, corrected, and reinforced where the original structure proved inadequate. Then the slide mechanism is set up and only then is the seal addressed.
That sequence matters. Every step depends on the one before it, and skipping to the seal is why these get repaired repeatedly.
Frequently Asked Questions
My bunk end keeps leaking despite new seals.
The opening has distorted or the bunk is sagging on worn slides. Either drops the sealing surface out of plane and a new seal cannot compensate.
Can you repair the bunk slide mechanism?
Yes. Slide mechanism repair runs $600 to $6,500 at 4 to 30 labor hours, including correcting the sag that causes most sealing complaints.
Do you replace bunk end tent fabric?
Where a soft bunk end is used, yes, as part of the repair. Fabric replacement runs $400 to $3,500.
How much does expandable trailer repair cost?
Most expandable work runs $600 to $10,000 depending on whether the wall opening needs structural correction.
Services We Perform on This Vehicle
Related Vehicles
We Can Help. Contact Us Today.
Bring the vehicle to our Yorba Linda facility and we will document the damage properly, work directly with your carrier, and give you a written figure built from published rates and real labor hours.
All work is performed at our Yorba Linda facility. We do not offer mobile, roadside or fleet route service.